Ultra-Low Sulfur in Automotive Fuels
Application Notebook
Globally, the permitted sulfur limit in fuel oils has been decreased to 10 ppm in many countries and regions.
Globally, the permitted sulfur limit in fuel oils has been decreased to 10 ppm in many countries and regions. For compliance verification, X-ray fluorescence (XRF) spectrometry is the definitive analysis tool for use at distribution terminal and refineries, as well as mobile or stationary testing laboratories
Rigaku Micro-Z ULS is a benchtop wavelength dispersive X-ray fluorescence (WDXRF) spectrometer with fixed optics optimized for sulfur analysis. The atmosphere in the optics path of the Micro-Z ULS is a vacuum so that helium gas is not required. The spectrometer is designed to minimize the restrictions in installation such as cooling water, special power supply, installation space, etc.
Experimental Conditions
Micro-Z ULS is equipped with an air-cooled 40 W Cr-target X-ray tube and a doubly curved RX-9 analyzing crystal optimized for low concentration sulfur. The counting time was 300 s for peak and background measurements. 4.0 mL of each diesel fuel sample was poured into a liquid XRF cup (inner diameter 35 mm) equipped with 2.5 μm Mylar® film.
Figure 1: Calibration results for diesel fuel.
Results
Repeatability tests were carried out using a representative sample. For each, two aliquots were prepared and analyzed using the calibration shown in Figure 1; this process was repeated 20 times. The test results are tabulated in Table I for diesel fuel, in which the average and the difference of two aliquots are shown respectively. Lower-limit-of detection (LLD) was calculated as 0.3 ppm sulfur.
Table I: Repeatibility results for diesel fuel
Conclusion
Low concentration sulfur in petroleum-based fuel can be routinely analyzed with high accuracy and precision with the Micro-Z ULS, a benchtop WDXRF spectrometer with fixed optics, which does not require He gas, external water supply or special power supply. This application note demonstrates that the performance of the Micro-Z ULS meets the requirements of ASTM D2622-10.
Rigaku Corporation
9009 New Trails Drive, The Woodlands, TX 77381
tel. (281) 362-2300, fax 281-364-3628
Website: www.Rigaku.com
The 2024 Emerging Leader in Atomic Spectroscopy Award
January 1st 2024This year’s Emerging Leader in Atomic Spectroscopy Award recipient is Eduardo Bolea-Fernández. For the past decade, Bolea-Fernández’s research has focused on the development of a newly introduced technique, termed tandem ICP-mass spectrometry (ICP-MS/MS), for ultra-trace elemental and isotopic analysis. Senior technical editor Jerome Workman discusses Bolea-Fernández’s work here.
Advancements in Non-Invasive Analysis of Historical Metal Artifacts
December 19th 2023Studying historical ancient artifacts requires the use of a nondestructive technique to analyze the metal surfaces of these objects. This study presents two approaches that improves on existing methods when conducting alloy analysis.
