Dept. of Nano Semiconductor Engineering, Korea Maritime University

Analyzing the effect of UV LED modules on disinfecting ballast water using UV–vis spectroscopy. 

Ballast water is seawater that fills a ship to maintain its balance. Annually, about 10 billion tons of ballast water with organisms such as planktons, germs, and bacteria is being transported around the world, and they cause diseases and contamination of marine ecology. UV treatment has the advantage of having no remaining toxic and disinfection by products (DBPs). Selective monochromatic wavelengths can be applied in the UV. Besides this UV LED modules have a low power consumption rate and only a 10~100 (mA) applied current. 

Therefore, UV LED modules were designed and fabricated to analyze the disinfection characteristics of UV LED with wavelengths of 255, 265, and 280 nm on phytoplankton such as 

To analyze the optical spectrum characteristics of the fabricated UV LED modules, a spectrometer (Avaspec-3648, Avantes) was used.  

Figure 1: Avantes spectrum of the UV LED modules. 

The UV LED modules that were used in the experiment showed peak wavelengths at 255, 265, and 280 nm and approximately 10 nm full widths at half maximum (FWHM). Because the UV LED had the characteristics of a monochromatic wavelength that does not show its spectrum in ranges except for those mentioned above, selective UV irradiation was possible (1). 

 sp. showed to be in accordance with the energy that was irradiated onto each UV LED module. The results show that the more the energy that was irradiated, the higher the disinfection rate was. 

 sp., the valid disinfection area was formed within the wavelength of the UV-C, and especially the highest disinfection rate occurred between 260 nm and 270 nm. 

Figure 2: Shape of the Tetraselmis sp. before and after the UV treatment. While the Tetraselmis sp. clearly showed a round cell membrane before the UV treatment, the shape of the cell membrane was transformed after the UV treatment (2). 

 sp. before and after the UV treatment. While the 

 sp. clearly showed a round cell membrane before the UV treatment, the shape of the cell membrane was transformed after the UV treatment (2). 

(2) Xiaoli Zhou, Muqing Liu, Yong Qian, Hui Wang, and Shaolong  Zhu, 

9769 W. 119th Dr., Suite 4, Broomfield, CO 80021 

tel. (303) 410-8668 or (866) 678-4248, fax (303) 410-8669 

Articles

Analyzing the effect of UV LED modules on disinfecting ballast water using UV–vis spectroscopy.

Dept. of Nano Semiconductor Engineering, Korea Maritime University

Articles

Disinfection of Tetraselmis sp. with UV LED Application